Gordon's Permasil #808 Carnauba Wax Mold Release (Blue Label)
|
- MANUFACTURER'S NAME: M.J. GORDON COMPANY
- ADDRESS: P.O. BOX 4441; PITTSFIELD, MASSACHUSETTS
- 24 HOUR EMERGENCY TELEPHONE NUMBERS: C H E M T R E C
Outside of the U.S. (703) 527-3887 Within the U.S. (800) 424-9300
- CORPORATE CONTACT NUMBERS: Phones: (413) 448-6066 or (888) 463-1044
Fax: (413) 448-2932
- NAME OF PERSON RESPONSIBLE FOR PREPARATION: Allan B. Gordon
- DATE PREPARED: January 1,
Section 1: IDENTITY |
|
A. |
Common Name: 9Trade Name & Synonyms |
 |
(Used on Label) GORDON'S PERMASIL #808 "Aqueous" (BLUE) CARNAUBA WAX MOLD RELEASE< p> |
|
B. |
CAS NO.: |
|
See Section 2 |
|
C. |
Chemical Name: |
|
Carnauba Wax Dissolved in various organic solvents propelled by Hydrocarbon |
|
D. |
Chemical Family: |
|
Mold Release |
|
E. |
Formula: |
|
Not Applicable. |
Section 2: HAZARDOUS INGREDIENTS (Principal Hazardous Components): |
Chemical and Common Names |
CAS # |
TLV |
Vapor Pressure at 20° C |
LEL |
UEL |
Flash Pt. °F |
Dimethyl Ether |
115-10-6 |
1000 ppm |
71 psig |
3.4 |
18.0 |
-42 (TCC) |
NOTE: Refer to Section 8 for content breakdown and SARA TITLE III information. | |
Section 3: PHYSICAL AND CHEMICAL CHARACTERISTICS (Fire and Explosion Data) |
|
A. |
Boiling Point (°F.): |
 |
Concentrate Range: 212 Propellant: -13 |
|
B. |
Specific Gravity (Water = 1): |
|
Concentrate: 1.o Propellant: 0.66 |
|
C. |
Vapor Pressure (mm Hg): |
|
See Section 2 |
|
D. |
Percent Volatile by Volume: |
|
Approximately 98% |
|
E. |
Vapor Density (Air = 1): |
|
1 |
|
F. |
Evaporation Rate (BA = 1): |
|
1 |
|
G. |
Solubility in Water: |
|
Complete. |
|
H. |
Reactivity in Water: |
|
None. |
|
I. |
Appearance and Odor: |
|
CONCENTRATE: Milky white liquid PROPELLANT: Clear, odorless gas. FINISHED PACKAGE: Pressurized containers. |
|
J. |
Flash Point: |
|
See Section 2 |
|
K. |
Flammable in Air (% by Vol.): |
|
See Section 2 |
|
L. |
Extinguisher Media: |
|
Dry Chemical, foam, carbon dioxide. |
|
M. |
Auto Ignition Temperature: |
|
Unknown. |
|
N. |
Special Fire Fighting Procedures: |
|
Water may be used to cool closed containers to avoid pressure build up and possible bursting when exposed to high temperatures. Firemen should wear self-contained respiratory protection. Hazardous decomposition products. |
|
O. |
Unusual Fire and Explosion Hazards: |
|
Although Aerosol is classified as non-flammable under ASTM D 3065-77 Flame Projection Test, this product should not be used near nor stored near any open flame or ignition source. Contents under pressure. Do not use or store near heat or ignition sources. Containers may burst at temperatures above 130° F. |
Section 4: PHYSICAL HAZARDS |
|
A. |
Stability: |
 |
Stable. |
|
B. |
Conditions to Avoid: |
|
Avoid any ignition source. Avoid excessive heat. |
|
C. |
Incompatibility (Materials to Avoid): |
|
Strong oxidizers. |
|
D. |
Hazardous Decomposition Products: |
|
Carbon monoxide, carbon dioxide. |
|
E. |
Hazardous Polymerization: |
|
Will not occur. Conditions to avoid not applicable. |
Section 5: HEALTH HAZARDS |
|
A. |
Threshold Limit Value: |
 |
See Section 2 |
|
B. |
Signs and Symptoms of Exposure: |
|
EYE CONTACT: May cause pain. May cause slight transient irritation with slight transient corneal injury. Vapors may irritate eyes;
SKIN CONTACT: Prolonged contact may cause irritation, defatting of skin;
INHALATION: Overexposure by inhalation of the vapors may cause nonspecific discomfort such as nausea, headache, or weakness. Higher exposures to the vapors may cause temporary nervous system depression with anesthetic effects such as dizziness, headache, confusion, incoordination, and loss of conciousness; or increased susceptibility to the cardiac arrythmic effects of epinephrine.
INGESTION: Ingestion is not considered to be a route of exposure. Ingestion of concentrate is not known to cause any health hazards. |
|
C. |
Chemical Listed As Carcinogen or Potential Carcinogen: |
|
- National Toxicology Program........NO
- I.A.R.C. Monographs.....................NO
- OSHA............................................NO
|
|
D. |
OSHA Permissible Exposure Limit: |
|
See Section 2 |
|
E. |
ACGIH Threshold Limit Value: |
|
See Section 2 |
|
F. |
Other Exposure Limit Used: |
|
None. |
EMERGENCY AND FIRST AID PROCEDURES
- INHALATION: Remove to fresh air. If not breathing, give mouth-tomouth resuscitation. If breathing is difficult, give oxygen. Do not give epinephrine or similar drugs. Call a physician.
- EYES: Flush with flowing water immediately and continuously for 15 minutes. Consult medical personnel.
- SKIN: Wash off in flowing water or shower. Remove contaminated clothing and wash before reuse.
- INGESTIONS: Do not induce vomiting. Call a physician immediately.
BECAUSE OF A POSSIBLE INCREASED RISK OF ELICITING CARDIAC DYSRHYTHMIA, CATECHOLAMINE DRUGS, SUCH AS EPINEPHRINE, SHOULD BE CONSIDERED ONLY AS A LAST RESORT IN LIFE THREATENING EMERGENCIES |
Section 6: SPECIAL PROTECTION INFORMATION |
|
A. |
Respiratory Protection: |
 |
NIOSH or Bureau of Mines approved organic vapor-type respirator is required in absence of proper environmental control. |
|
B. |
Ventilation: |
|
- Local Exhaust ...............To keep below TLV
- Mechanical (General)....To keep below TLV Special
- Special...........................None
- Other..............................None
|
|
C. |
Protective Gloves: |
|
Solvent resistant gloves; impervious gloves. |
|
D. |
Eye Protection: |
|
Safety Glasses or Goggles. |
|
E. |
Other Protective Clothing or Equipment: |
|
None reasonably foreseeable. |
Section 7: SPECIAL PROTECTION INFORMATION |
|
A. |
Precautions to be taken in Handling and Storage: |
 |
Do not store above 120°F. Avoid breathing vapors. Vapors are heavier than air and will collect in low areas. Avoid prolonged or repeated contact with skin. Do not store near open flames or any other ignition source. |
|
B. |
Other Precautions: |
|
Contents under pressure. Do not puncture or incinerate. |
|
C. |
Steps to be Taken in Case Material is Released or Spilled: |
|
SMALL SPILLS: Remove ignition sources. Mop up, wipe up, or soak up immediately. Use proper protective equipment.
LARGE SPILLS: Evacuate area. Remove ignition sources. Contain liquid; transfer to closed containers; keep out of water supplies. |
|
D. |
Waste Disposal Methods: |
|
Dispose in accordance with Federal, State, and local regulations. Do not incinerate closed or empty containers. |
Section 8: PERCENTAGES OF HAZARDOUS INGREDIENTS (Principal Hazardous Components): |
Chemical & Common Names |
CAS # |
% By Weight |
Subject to Section 313 SARA Title III |
Dimethyl Ether |
115-10-6 |
30 % |
No |
These chemicals are reported on the United States Environmental Protection Agency TOXIC SUBSTANCES CONTROL ACT INVENTORY (TSCA).
NOTE: Teh remaining ingredients, 70%, consist of approximately 69% water and less than 1% Carnauba Wax.
THE INFORMATION HEREIN IS GIVEN IN GOOD FAITH, BUT NO WARRANTY, EXPRESS OR IMPLIED IS MADE. | |
IDENTITY
HAZARDOUS INGREDIENTS
PHYSICAL AND CHEMICAL CHARACTERISTICS
PHYSICAL HAZARDS
HEALTH HAZARDS
SPECIAL PROTECTION INFORMATION
PERCENTAGES OF HAZARDOUS INGREDIENTS |